Product ID:AEROSOL SPRAY PAINT, 0317 ALUMINUM
MSDS Date:03/23/1988
FSC:8010
NIIN:00N023334
MSDS Number: BLZVZ

Emergency Phone: 213-513-0700;800-424-9300(CHEMTREC)

Info Phone: 213-513-0700

Cage: 25461

Telephone: 310-513-0700

Cage: 25461

NO INGREDIENT FOR THIS FORMULATION_INGREDIENT

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INGEST: GI DISTRESS. INHAL: OVEREXP
MAY CAUSE NOSE/THROAT IRRIT. MAY CAUSE CNS EFTS SUCH AS DIZZ, HDCH,
NAUS, STAGGERING GAIT, CONFUSION & UNCON. REPORTS HAVE ASSOCIATED
RPTD & PRLNGD OVEREXP TO SOLV W/PERM BRAIN/NERVOUS SYS DMG. EYE
WATERING, HEADACHE, NAUSEA, DIZZINESS & LOSS OF COORDINATION (EFTS
OF OVEREXP)
Explanation of Carcinogenicity:METHYLENE CHLORIDE: GROUP 2 (NTP), GROUP
2B (IARC).
Effects of Overexposure:HLTH HAZ: ARE SIGNS THAT SOLV LEVS ARE TOO
HIGH. SKIN/EYE: MAY CAUSE EYE IRRIT/BURNING OF EYES. RPTD/PRLNGD
LIQ CONT MAY CAUSE SKIN IRRIT W/DISCOMFORT/DERM. CHLOROCARBON MATLS
HAVE PRDCD SENSIT OF MYO CARDIUM TO EPINEPHRINE IN LAB ANIMALS
&COULD HAVE SIMILAR EFT IN HUMANS. (SUPP DATA)
Medical Cond Aggravated by Exposure:HEAVY SMOKERS AND THOSE WITH HEART
DISEASE MAY EXPERIENCE AN INCREASED RISK OF HEART PROBLEMS.

First Aid:INGEST: IN UNLIKELY EVENT OF INGEST, CALL PHYS IMMED & HAVE
NAMES OF INGREDS AVAIL. DO NOT INDUCE VOMIT. INHAL: REMOVE TO FRESH
AIR. IF NOT BRTHG, GIVE ARTF RESP, PREFERABLY MOUTH TO MOUTH. IF
BRTHG D FCLTY PERSISTS, OR OCCURS LATER, CONSULT PHYS. EYE: IMMED
FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINUTES; CALL PHYS. SKIN:
WASH WITH SOAP AND WATER. IF IRRIT OCCURS, CONT PHYSICIAN.

Flash Point Method:COC
Flash Point:<20F,<-7C
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD PRESS DEMAND SCBA& FULL
PROT EQUIP.H*2O MAY BE INEFFECTIVE.H*2O FROM FOG NOZ MAY BE USED TO
COOL CLSD CNTNRS TO PVNT PRESS BUILD-UP.
Unusual Fire/Explosion Hazard:CONT UNDER PRESS. KEEP AT ROOM TEMP AS
EXPOS TO SUNLIGHT/OTHER HEAT MAY CAUSE CANS TO BURST,PROPELLING
CONT ACROSS AREA.THERM DECOMP PRODS MAY INCL (SUP DATA)

Spill Release Procedures:VENTILATE AREA. REMOVE SOURCES OF IGNITION.
PREVENT SKIN CONTACT AND BREATHING OF VAPOR. CONFINE AND REMOVE
WITH INERT ABSORBANT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:OBSERVE LABEL PRECAUTIONS. KEEP AWAY
FROM HEAT, SPARKS AND FLAME. DO NOT STORE ABOVE 120F. DO NOT EXPOS
TO DIRECT SUNLIGHT TO AVOID BURSTING.
Other Precautions:WASH THORO AFTER HANDLING AND BEFORE EATING AND
SMOKING.DO NOT SAND/FLAME CUT/BRAZE/WELD DRY COATING W/OUT
NIOSH/MSHA APPRVD RESP/APPROP VENT. DO NOT PUNCTURE. DO NOT SPRAY
NEAR FIRE/OPEN FLAME. NO SM OKING IN AREA OF USE. DO NOT USE (ING
9)

Respiratory Protection:DO NOT BREATHE VAPORS/MISTS. WEAR A NIOSH/MSHA
APPROVED APPROPRIATE, PROPERLY FITTED RESP DURING AND AFTER
APPLICATION UNLESS AIR MONITORING DEMONSTRATES VAPOR/MIST LEVELS
ARE BELOW APPLIC LIMITS. FOL LOW RESP MFR'S DIRECTIONS FOR RESP
USE.
Ventilation:PROVIDE SUFFICIENT VENT IN SOLV & PATTERN TO KEEP
CONTAMINANTS BELOW APPLICABLE OSHA REQUIREMENTS.
Protective Gloves:NEOPRENE GLOVES.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:COVERALLS. PROTECTIVE CREAMS MAY BE USED FOR
EASE OF CLEAN-UP, NOT FOR PROTECTION.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SOL IN H*2O: APPRECIABLE, DEPENDING ON COLOR. % VOLAT: VOL: 92%
TYPICAL; WT: 85% TYPICAL. EXPLO HAZ: HCL & PHOSGENE . EFTS OF
OVEREXP: ADRENOMIMETICS (E.G., EPINEPHRINE) MAY BE CONTRAINDICATED
E XCEPT FOR LIFE-SUSTAINING USES IN HUMANS ACUTELY/CHRONICALLY
EXPOS TO CHLOROCARBONS .

HCC:V3
Boiling Pt:B.P. Text:<0F,<-18C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Evaporation Rate & Reference:FASTER THAN ETHER
Solubility in Water:MODERATE-(SUPP DATA)
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:SUPDAT

Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:STORAGE ABOVE 120F.
Hazardous Decomposition Products:CO, CO*2, SMOKE, OXIDES OF HEAVY
METALS REPORTED IN INGREDIENTS SECTION. HCL, PHOSGENE .

Waste Disposal Methods:DO NOT ALLOW MATERIAL TO CONTAMINATE GROUND
WATER SYSTEMS. INCINERATE ABSORBED MATERIAL IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL REQUIREMENTS. DO NOT INCINERATE IN CLOSED
CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.